Mast Up!

Originally I was going to hire a rigger to rig my mast – but in the end I decided to save a few dollars and do it myself. I’m really happy I did. Again, it was a great educational experience to learn, make a few mistakes and feel confident knowing every part of the boat. Ruben at Seamark Marine used a hoist to raise the mast which made the job a cinch.

Advertisements

New Bunks

With Mia Noi off the trailer for the first time, it gave me a chance to check out the condition of the wood bunks. I was horrified when I pulled back a small section of the carpet. The wooden bunks were rotten thru – I was lucky they had supported the weight of the boat this long. It turned out to be a quick and easy job to replace the bunks – the job took about 4-hours total.

Test Drive

More than two months after I purchased ‘Mia Noi’, I finally got to give her a ‘road test’ in Marina Del Rey. It was a great feeling to drive off from Seamark Marina with ‘Mia Noi’ in tow. I was a little trepid as a reversed the trailer down the ramp – wondering in the  back of my mind if ‘Mia Noi’ would sink or float as her transom began to touch the salt water of the Pacific Ocean! The outboard started immediately using the electric start. Afloat .. I took ‘Mia Noi’ for her first ‘motor’ around Marina Del Rey, happy my dreams were coming true!

A Sailor’s Best Friend

When I purchased ‘Mia Noi’ she came with an 8HP two-stroke outboard. She started – was a little smokey and would do the job. But, for safety reasons and personal reassurance I purchased an new four-stroke Nissan 8HP outboard. It’s a good fit for my Catalina and I wanted to make sure I had a best friend out on the water if the weather turned un-friendly! The transom was reinforced with a plastic plate to assist in accommodating the 90 pound outboard, I also purchased a new bracket for the engine.

Seamark Marine

The refurbishment of my Catalina 22 was completed by Seamark Marine at Marina Del Rey. Ruben Flores, Seamark Marine’s Owner/Operator is honest, generous with his time and advice – plus he did a great job painting and repairing my Catalina 22 ‘Mia Noi’. Ruben allowed me to do the small stuff, such a re-wiring the mast and removing the hardware from ‘Mia Noi’. I recommend Seamark Marine if you need work done on your sailboat or motorboat. The majority of boat repair yards in Marina Del Rey prefer to work on new boats. Ruben and his team are different, old or new – no job is too difficult and you’ll be happy with the results.

Spray Job – The Body Paint

Finally Los Angeles’ unseasonably wet weather turned back to its traditional 85 degrees and sunshine – and the final deck coat was sprayed on. Ruben Flores and his Seamark Marine team prepped the boat and went to work painting ‘Mia Noi’.

Parking Spot

A major reason I purchased ‘Mia Noi’ is because of her trailerbility. In Marina Del Rey, Los Angeles County Department Of Beaches and Harbors has a mast up storage facility. I was able to get a spot in the mast up storage area, 50 meters from the boat ramp.

Trailer Upgrade

The original air-brake coupler on the trailer was very stiff and difficult to mount and remove from my Jeep’s hitch. So I decided to grind, cut off the air-brake coupler and replace it with a simple trigger latch coupler.

Mast Step Plate

As I was upgrading to ‘all lines aft’, I needed to install a mast step halyard plate. The mast step currently on the boat needed a bit of elbow grease to remove, it had been updated and installed by the previous owner about 12 months before I purchased the boat.

Wood Work 102

My living room looked and smelt like a wood workshop for several weeks while I undertook the lengthly process of sanding and varnishing the external teak and mahogany handrails and sliders. I had a companion way trim set custom made in Florida by Woodshop 102. Rex Rothing did a great job cutting the pieces and he was cheaper than purchasing the plastic version offered by Catalina Direct. I did however decided to replace the cockpit coaming compartment trim with the plastic trim from Catalina Direct.